[plane engine whirring]
These pilots are flying what's called a Super Scooper.
At around $30 million, it's one of the most expensive
aerial-firefighting aircraft ever made.
Tim Sheehy: It's literally a boat with giant wings,
and it's built like a tank.
It looks like no other plane in the world.
Narrator: The CL-415 Enhanced Aerial Firefighter
can scoop and drop 1,400 gallons of water on wildfires
in a matter of minutes.
Compare that to this 1970s plane,
which could only drop 200 gallons of water at a time.
Sheehy: $30 million is very expensive for any aircraft.
However, it's actually the most cost-effective
aerial-firefighting asset.
Narrator: Super Scoopers revolutionized
aerial firefighting, and Insider got an up-close look
with Bridger Aerospace to see how this aircraft
is tailor-made to fight fires.
Airplanes have been used to fight wildfires
for almost 100 years,
but early attempts weren't nearly as effective.
Sheehy: In the '50s and '60s, almost all the aircraft
used to fight fires were retired
or salvaged World War II aircraft.
Tanks were strapped to the middle,
and they were used in a very haphazard, provisional manner.
Narrator: Some of these
makeshift firefighting planes
were only able to drop
150 to 200 gallons of water at a time.
Sheehy: Not really effective in today's world,
but at the time, it was the best they could do.
Narrator: Canadair was contracted
to design a plane specifically to fight fires.
Sheehy: So they designed the grandfather
of this airplane, the CL-215.
It looked very similar.
Narrator: Which Viking Air Ltd. modernized in 2020,
retrofitting the CL-215 with a new avionics system,
turbine engines, and more.
Sheehy: It was taken down to its bones
and created, essentially, a new airplane.
Narrator: Weighing in at 30,000 pounds,
the CL-415EAF is 30 feet tall
and has a 93-foot wingspan,
just 24 feet shy of a
Boeing 737's wingspan.
Sheehy: When up close to
it, you really appreciate
just the massive size of it.
Narrator: But despite its size,
the aircraft was engineered
to fly like a much smaller plane.
Sheehy: When you look at them, they don't necessarily
look like they'd be an aerobatic or stunt plane.
We're taking a plane almost the size of a C-130,
we're flying it into extremely narrow canyons,
very low altitude,
banking high-g turns at a high rate of turn.
Flying an aircraft this big, that low,
in that dangerous of an environment is very rare.
Narrator: The Scooper is so nimble
because of its flight-control surfaces,
or aerodynamic devices that pilots use to adjust
and control the aircraft.
On any plane, the main
control surfaces are
the ailerons, which
control the plane's roll;
the rudder, which controls yaw,
or the aircraft's direction;
and elevators, which control
the aircraft's pitch.
And in the case of the Super Scooper,
those flight-control surfaces are supersized.
Sheehy: That's important, because when you're flying
slow and big,
you need to have a lot of aileron area,
a lot of elevator area to be able to move that aircraft
as quickly as you need to at those low speeds.
Narrator: That's why this rudder is 25 square feet larger
than that of a Boeing 737-900,
even though the Super
Scooper is 10 feet shorter
and half as long.
This is crucial for the Scooper.
It needs to slow down to 90 knots,
or just over 100 miles per hour, to perform a scoop.
That's almost half the aircraft's standard cruising speed.
Sheehy: Once you've identified your scoop site
and you're coming in, you go through
your pre-pickup checklist.
One of those items is "probe down."
Pilot: Probes are down.
Sheehy: The way the aircraft picks up water,
as it does not stop or suck it up,
there's no vacuum, it scoops it.
And it scoops it through what you see here,
two probes on either side of the keel of the aircraft,
about the size of your hands put together,
and as soon as you hit the water, they catch.
You can feel it in the cockpit.
You've got to be ready for that catch with the yoke.
Pilot: Right there, get ready to add some power. Now.
Sheehy: And the water begins filling almost immediately.
Narrator: It takes the Scooper 12 seconds
to fill its tanks with 1,400 gallons of water,
during which time the pilot has to maintain
the plane's speed and direction.
Sheehy: Once the aircraft is full and the tanks are full,
you retract the probes.
There is a noticeable surge in the aircraft
when those probes go up.
Get the aircraft back up to speed and take off.
Narrator: Now 11,000 pounds heavier,
the aircraft relies on its design
to ascend from the surface.
Barrett Farrell: If you look at the wing,
you can see it has a very large curvature to it.
That's called camber,
which creates an enormous amount of lift.
Narrator: But aerodynamics
aren't the only factor involved.
The plane is outfitted with turboprop engines
that generate more than enough power
to lift it off the surface.
Ben Turner: They make 2,380 shaft
horsepower, each side.
Sheehy: These things are extremely durable.
You never want to hit
anything with them, of course,
but if it's ash or debris being pushed up
through the thermals of the fire,
these engines are going to chew right through that
and keep running.
Narrator: All that enables the Scooper
to ascend back up to its previous altitude
in roughly three minutes.
Pilot: Scooper 282 is inbound, loaded for the drop.
Farrell: So, when we're lining up for a drop,
the air attack will get us on target.
They're in contact with the folks on the ground,
who are requesting the water.
We're factoring in the terrain, the wind, our altitude
for when we need to press the button to make the drop.
Narrator: When the pilot is ready to drop the load,
they'll press the water-drop button...
Pilot: And three, two, one, drop.
Narrator: Opening the drop doors on the keel
and releasing 1,400 gallons of water.
Pilot: Load's away.
Narrator: It only takes two seconds
for the aircraft to drop its entire load,
a very short window for the pilot to work with.
Farrell: There is no targeting computer.
It's all by feel and by experience.
Narrator: But the Super Scooper's high-lift wing
and turboprop engines allow it to attack forest fires
from a lower altitude and speed
than other firefighting aircraft.
While planes like the
747 Supertanker and DC-10
make drops from between 200 and 800 feet,
the Super Scooper can do so
from as low as 100 feet above a fire.
Sheehy: When you're fighting fire at low altitude,
flying through mountains and smoke and trees,
having the ability to quickly adjust
to terrain variations, other aircraft in the area,
or obstacles that emerge through the smoke
is very important.
Narrator: After performing the drop,
the Scooper can simply head back to the water source
to pick up another load,
rather than refilling on the ground.
Farrell: So, from drop to drop, it really depends
on how close our water source is,
but I've been on fires
where we're dropping a load of water every six minutes.
Narrator: The aircraft can go up to six hours
between refuels, depending on conditions,
meaning it can fight fires longer than other aircraft
that need to refuel every two hours.
Sheehy: Although the sticker price on the aircraft
is very expensive, it can deliver 150,000 gallons
in one service day,
compared to a more traditional tanker
that can oftentimes only do a small fraction of that.
It's actually the most cost-effective
aerial-firefighting asset.
Narrator: And with a paint job like that,
it can be hard to miss.
Turner: It's a very flashy paint job on these aircraft,
and it's one of the questions we're asked quite often,
is, why is it painted the way it is?
The goal is to be visible in this super-dense smoke.
It's a very action-packed circuit
when these guys are fighting the fires,
and safety is the ultimate goal.
Narrator: For aerial firefighters,
the next game-changing innovations
aren't going to come to the planes themselves.
Sheehy: The next ridgeline for aerial firefighting
is going to be data.
It's going to be understanding what the fire is doing,
where it's going, where it's came from,
and being able to share that data
with as wide a population as possible.
That can better inform our aerial response,
better inform the ground response,
and make sure that those citizens affected by the incident
are given the best information possible
to protect themselves, their families, and their livelihood.
Narrator: In the meantime,
aerial-firefighting aircraft
like the Super Scooper
are tasked with keeping
forest fires in check.
Sheehy: Flying this aircraft
in the environment we fly it in,
it's very exciting, it's very dangerous,
but it's also very fun.